To get around the fluid specific lubricant requirement, dodge there was a couple of Asian companies making bronze synchro rings.
Thoroughly clean the mounting surface of any sealant, then spray a lint free rag with a solvent (brake cleaner, carb cleaner, etc) and wipe the surface clean of any oil.
Mopar Synthetic fluid 75W-85 Trans Lube (NV4500 manual).
QU90020 is a full synthetic, API Service GL-4 manual transmission lubricant specifically formulated for smooth shifting and outstanding protection under a wide range of operating extremes including low and high temperature conditions.Use the handy Links below to access over 40 manual years of Dan's product and vehicle specific Tech Notes to easily get the information you need for your vehicle's repair, maintenance, or upgrade project!These are the only lubricants recommended by New Venture Gear for the NV4500: 75W-90, castrol Syntorque, synthetic, mopar Synthetic Manual Transmission Lubricant Mopar P/N 4874459 (Material Specification 9070) 2, gM Goodwrench Synthetic Manual Transmission Fluid (GM Part.OnDemand video tutorials, or get the online manual, or our traditional printed manual.Case material: Cast Iron.Castrol's fluid is difficult, if not impossible to locate (it may be discontinued but both General Motors and Chrysler continue to sell the formulation under their own brands. The transmission's fibrous synchronizers designate fluid particularly specific fluid specifications - failure to use a suitable gear oil will result manual in fluid transmission damage.
Castrol discontinued Syntorq LT a few years after NV4500 production ended in 2006.
See fluid information above; only use a suitable prison fluid as discussed above or transmission damage will occur.QU90005.5 oz Ultra Black RTV Sealant.If operated in "severe conditions check brakes for wear and condition every dodge 3 months or 3,000 miles, and change the differential fluid every 12,000 miles * If the vehicle is frequently used full for towing, operated in continuous stop-and-go traffic, high heat, sub-zero, or mountainous.However, it must be checked and adjusted if it has been removed and reinstalled.S24200 ) claudia to your existing bolts to prevent oil seepage past the bolt threads.Superseded by, in Canada 10953477).ZF 5 speed fluid replacement, nV4500 transmission specs, changing oil in a Dana 80 rear differential.NV4500 Transmission Fluid Spec, the NV4500 manual transmission is highly sensitive to its fluid type as it uses special carbon fiber synchronizers.New Venture Gear and used in General Motors and Chrysler products from 19912007.The cause of such failures has been attributed to frequent lugging of the engine; high load, low speed situations. You no longer break need to do a tune-up every six months or change the oil every three months, but regular service and check-ups are still manuals essential to your vehicles longevity.
QU90003 ) to seal between update the main case and input bearing retainer, top cover, and rear housing.
You may drain the fluid via this single PTO cover bolt, or you can remove the entire PTO cover.
What follows is our quick reference guide for the third modern generation Dodge Ram pickup truck the models are also includes, but their introduction lagged a year behind, so little information on the previous generation 2002 3/4 2000 dodge 3500 manual transmission fluid and 1-ton trucks is here.
The Chrysler part number is and the GM part number is 4637579.
I went to Royal Purples website and it says on there that for a NV4500 to use thier 75-90 Maxgear oil.